Numerical study of response behaviors of natural gas hydrate reservoir around wellbore induced by water jet slotting
Abstract view|104|times PDF download|47|times
Abstract
The trial production of natural gas hydrate reservoirs remains poor. Reasonable reservoir reconstruction, which can improve formation permeability, is an important approach to increasing the efficiency and enhancing production. In this work, water jet slotting is proposed to reconstruct an natural gas hydrate reservoir near a wellbore. The spatial slots formed by water jet slotting not only directly constitute high-permeability channels, but also generate disturbances to the surrounding in-situ sediment. Water jet slotting disturbances to nearby sediment was investigated using a three dimensional flow-structure coupling model to evaluate the proposed reconstruction method. The reservoir at the SH2 site in the Shenhu area of the South China Sea was used as the reference. A horizontal slotting arrangement along the vertical well was adopted. The results demonstrate that water jet slotting can change the primary stress state of the sediment around the wellbore, and generate a dominant stress relaxation zone and small stress concentration zone. Within the stress relaxation zone, the in-situ compressive stress was remarkably reduced or even transformed into tensile stress, accompanied by sediment displacement and volumetric expansion strain. This is conducive to loosening the sediment around the wellbore and improving the permeability characteristics. In addition, the influence of the water jet slotting parameters including slot radius, spacing, and number on disturbances to the nearby sediment was studied. Reservoir responses to water jet slotting under balanced and unbalanced bottom-hole pressures were compared and analyzed. This study provides a reference for natural gas hydrate reservoir reconstruction using water jet slotting.
Document Type: Original article
Cited as: Huang, M., Su, D., Zhao, Z., Wu, L., Fang B., Ning, F. Numerical study of response behaviors of natural gas hydrate reservoir around wellbore induced by water jet slotting. Advances in Geo-Energy Research, 2023, 7(2): 75-89. https://doi.org/10.46690/ager.2023.02.02
Keywords
Full Text:
PDFReferences
Biot, M. A. Mechanics of deformation and acoustic propagation in porous media. Journal of Applied Physics, 1962, 33(4): 1482-1498.
Cai, J., Xia, Y., Lu, C., et al. Creeping microstructure and fractal permeability model of natural gas hydrate reservoir. Marine and Petroleum Geology, 2020a, 115: 104282.
Cai, J., Xia, Y., Xu, S., et al. Advances in multiphase seepage characteristics of natural gas hydrate sediments. Chinese Journal of Theoretical and Applied Mechanics, 2020b, 52(1): 208-223. (in Chinese)
Chen, L., Feng, Y., Okajima, J., et al. Production behavior and numerical analysis for 2017 methane hydrate extraction test of Shenhu, South China Sea. Journal of Natural Gas Science and Engineering, 2018, 53: 55-66.
Chen, C., Yang, L., Jia, R., et al. Simulation study on the effect of fracturing technology on the production efficiency of natural gas hydrate. Energies, 2017, 10(8): 1241.
Cui, Y., Lu, C., Wu, M., et al. Review of exploration and production technology of natural gas hydrate. Advances in Geo-Energy Research, 2018, 2(1): 53-62.
Ebinuma, T., Kamata, Y., Minagawa, H., et al. Mechanical properties of sandy sediment containing methane hydrate. Paper Presented at Proceedings of 5th International Conference on Gas Hydrate, Trondheim, Norway, 12-16 June, 2005.
Feng, Y., Chen, L., Kanda, Y., et al. Numerical analysis of gas production from large-scale methane hydrate sediments with fractures. Energy, 2021, 236: 121485.
Feng, Y., Chen, L., Suzuki, A., et al. Enhancement of gas production from methane hydrate reservoirs by the combination of hydraulic fracturing and depressurization method. Energy Conversion and Management, 2019, 184: 194-204.
Feng, C., Li, S. H., Wang, L. X. A numerical method to solve pore seepage problems based on element local coordinate system. Rock & Soil Mechanics, 2014, 35(2): 584-590. (in Chinese)
Guo, W., Zhang, P., Wang, Y., et al. Evolution on the gas production from low permeability gas hydrate reservoirs by depressurization combined with reservoir stimulation. Energy & Fuels, 2020, 34 (12): 15819-15828.
Ito, T., Igarashi, A., Suzuki, K., et al. Laboratory study of hydraulic fracturing behavior in unconsolidated sands for methane hydrate production. Paper OTC 19324 Presented at the Offshore Technology Conference, Houston, Texas, USA, 5-8 May, 2008.
Ju, X., Liu, F., Fu, P., et al. Gas production from hot water circulation through hydraulic fractures in methane hydrate-bearing sediments: THC-coupled simulation of production mechanisms. Energy & Fuels, 2020, 34(4): 4448-4465.
Khodaverdian, M., Mcelfresh, P. Hydraulic fracturing stimulation in poorly consolidated sand: mechanisms and consequences. Paper SPE 63233 Presented at the SPE Annual Technical Conference and Exhibition, Texas, USA, 1-4 October, 2000.
Klar, A., Soga, K. Coupled deformation-flow analysis for methane hydrate production by depressurized wells. Paper Presented at 3rd International Biot Conference on Poromechanics, Oklahoma, USA, 25-27 May, 2005.
Klar, A., Soga, K., Ng, M. Coupled deformation-flow analysis for methane hydrate extraction. Geotechnique, 2010, 60(10): 765-776.
Konno, Y., Jin, A. Y., Yoneda, A. J., et al. Hydraulic fracturing in methane-hydrate-bearing sand. RSC Advances, 2016, 6(77): 73148-73155.
Kurihara, M., Sato, A., Funatsu, K., et al. Analysis of production data for 2007/2008 Mallik gas hydrate production tests in Canada. Paper SPE 132155 Presented at the International Oil and Gas Conference and Exhibition in China, Beijing, China, 8-10 June, 2010.
Li, Y., Liu, L., Jin, Y., et al. Characterization and development of natural gas hydrate in marine clayey-silt reservoirs: A review and discussion. Advances in Geo-Energy Research, 2021a, 5(1): 75-86.
Li, B., Ma, X., Zhang, G., et al. Enhancement of gas production from natural gas hydrate reservoir by reservoir stimulation with the stratification split grouting foam mortar method. Journal of Natural Gas Science and Engineering, 2020a, 81: 103473.
Li, Z., Wan, T., Liang, Q. The influence of reservoir reconstruction on the production capacity of natural gas hydrate. Ground Water, 2020b, 42(3): 120-124. (in Chinese)
Li, S., Wu, D., Wang, X., et al. Enhanced gas production from marine hydrate reservoirs by hydraulic fracturing assisted with sealing burdens. Energy, 2021b, 232: 120889.
Liang, Y., Tan, Y., Luo, Y., et al. Progress and challenges on gas production from natural gas hydrate-bearing sediment. Journal of Cleaner Production, 2020, 261: 121061.
Liu, J., Li, X. Recent advances on natural gas hydrate exploration and development in the South China Sea. Energy & Fuels, 2021, 35(9): 7528-7552.
Liu, L., Lu, X., Zhang, X., et al. Numerical simulations for analyzing deformation characteristics of hydrate-bearing sediments during depressurization. Advances in Geo-Energy Research, 2017, 1(3): 135-147.
Lu, C., Qin, X., Mao, W., et al. Experimental study on the propagation characteristics of hydraulic fracture in clayey-silt sediments. Geofluids, 2021: 6698649.
Ma, X., Cheng, J., Sun, Y., et al. 2D Numerical simulation of hydraulic fracturing in hydrate-bearing sediments based on the cohesive element. Energy & Fuels, 2021a, 35(5): 3825-3840.
Ma, X., Sun, Y., Guo, W., et al. Numerical simulation of horizontal well hydraulic fracturing technology for gas production from hydrate reservoir. Applied Ocean Research, 2021b, 112: 102674.
Makogon, Y. F. A gas hydrate formation in the gas saturated layers under low temperature. Gas Industry, 1965, 5: 14-15.
Makogon, Y. F. Natural gas hydrates-A promising source of energy. Journal of Natural Gas Science and Engineering, 2010, 2(1): 49-59.
Masuda, Y., Konno, Y., Iwama, H., et al. Improvement of near wellbore permeability by methanol stimulation in a methane hydrate production well. Paper OTC 19433 Presented at the Offshore Technology Conference, Houston, Texas, USA, 5-8 May, 2008.
Shaibu, R., Sambo, C., Guo, B., et al. An assessment of methane gas production from natural gas hydrates: Challenges, technology and market outlook. Advances in Geo-Energy Research, 2021, 5(3): 318-332.
Shen, P., Li, G., Li, X., et al. Application of fracturing technology to increase gas production in low-permeability hydrate reservoir: A numerical study. Chinese Journal of Chemical Engineering, 2021, 34: 267-277.
Sun, Y., Li, S., Lu, C., et al. The characteristics and its implications of hydraulic fracturing in hydrate-bearing clayey silt. Journal of Natural Gas Science and Engineering, 2021, 95: 104189.
Sun, J., Ning, F., Liu, T., et al. Gas production from a silty hydrate reservoir in the South China Sea using hydraulic fracturing: A numerical simulation. Energy Science & Engineering, 2019, 7(4): 1106-1122.
Terzaghi, K. Theoretical Soil Mechanics. New York, USA, John Wiley & Sons, 1943.
Too, J. L., Cheng, A., Khoo, B. C., et al. Hydraulic fracturing in a penny-shaped crack. Part I: Methodology and testing of frozen sand. Journal of Natural Gas Science and Engineering, 2018a, 52: 609-618.
Too, J. L., Cheng, A., Khoo, B. C., et al. Hydraulic fracturing in a penny-shaped crack. Part II: Testing the frackability of methane hydrate-bearing sand. Journal of Natural Gas Science and Engineering, 2018b, 52: 619-628.
Truesdell, C. The Linear Theory of Elasticity in the Encyclopedia of Physics. Berlin, Springer-Verlag, 1972.
Wanniarachchi, W., Ranjith, P., Perera, M. Shale gas fracturing using foam-based fracturing fluid: a review. Environmental Earth Sciences, 2017, 76(2): 91.
Wu, N., Li, Y., Wan, Y., et al. Prospect of marine natural gas hydrate stimulation theory and technology system. Natural Gas Industry B, 2021, 8(2): 173-187.
Wu, S., Liu, J., Xu, H., et al. Application of frequency division inversion in the prediction of heterogeneous natural gas hydrates reservoirs in the Shenhu Area, South China Sea. China Geology, 2022, 5: 251-266.
Yamamoto, K., Terao, Y., Fujii, T., et al. Operational overview of the first offshore production test of methane hydrates in the Eastern Nankai Trough. Paper OTC 25243 Presented at the Offshore Technology Conference, Texas, USA, 5-8 May, 2014.
Yamamoto, K., Wang, X., Tamaki, M., et al. The second offshore production of methane hydrate in the Nankai Trough and gas production behavior from a heterogeneous methane hydrate reservoir. RSC Advances, 2019, 9(45): 25987-26013.
Yang, Y., He, Y., Zheng, Q. An analysis of the key safety technologies for natural gas hydrate exploitation. Advances in Geo-Energy Research, 2017, 1(2): 100-104.
Yang, L., Shi, F., Yang, J. Experimental studies on hydraulic fracturing in hydrate sediment. Chemistry and Technology of Fuels and Oils, 2020, 56(1): 107-114.
Yao, Y., Guo, Z., Zeng, J., et al. Discrete element analysis of hydraulic fracturing of methane hydrate-bearing sediments. Energy & Fuels, 2021, 35(8): 6644-6657.
Ye, J., Qin, X., Xie, W., et al. The second natural gas hydrate production test in the South China Sea. China Geology, 2020, 3: 197-209.
Yin, Z., Linga, P. Methane hydrates: A future clean energy resource. Chinese Journal of Chemical Engineering, 2019, 27(9): 36-46.
Yu, T., Guan, G., Wang, D., et al. Gas production enhancement from a multilayered hydrate reservoir in the South China Sea by hydraulic fracturing. Energy & Fuels, 2021, 35(15): 12104-12118.
Yuan, Y., Xu, T., Xin, X., et al. Enhanced gas production from clayey-silt hydrate reservoirs based on near-well reservoir reconstruction using the high-pressure jet grouting technology. Journal of Natural Gas Science and Engineering, 2021, 94: 104121.
Yun, Q., Youhong, S., Bing, L. Numerical simulation study on the influence of near-well reservoir reconstruction on the depressurization and production characteristics of natural gas hydrate reservoirs. Drilling Engineering, 2021, 48(4): 85-96. (in Chinese)
Zhang, W., Shi, X., Jiang, S., et al. Experimental study of hydraulic fracture initiation and propagation in highly saturated methane-hydrate-bearing sands. Journal of Natural Gas Science and Engineering, 2020, 79(77): 103338.
Zhao, J., Xu, L., Guo, X., et al. Enhancing the gas production efficiency of depressurization-induced methane hydrate exploitation via fracturing. Fuel, 2021, 288: 119740.
Zhong, X., Pan, D., Zhai, L., et al. Evaluation of the gas production enhancement effect of hydraulic fracturing on combining depressurization with thermal stimulation from challenging ocean hydrate reservoirs. Journal of Natural Gas Science and Engineering, 2020, 83: 103621.
Zhong, X., Pan, D., Zhu, Y., et al. Fracture network stimulation effect on hydrate development by depressurization combined with thermal stimulation using injection-production well patterns. Energy, 2021, 228: 120601.
Zhou, S., Zhao, J., Li, Q., et al. Optimal design of the engineering parameters for the first global trial production of marine natural gas hydrates through solid fluidization. Natural Gas Industry B, 2018, 5(2): 118-131.
DOI (PDF): https://doi.org/10.46690/ager.2023.02.02
Refbacks
- There are currently no refbacks.
Copyright (c) The Author(s)
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.