Predicting adsorbed gas capacity of deep shales under high temperature and pressure: Experiments and modeling
Abstract view|146|times PDF download|81|times
Abstract
Temperature and pressure conditions of deep shale are beyond experiment range, and the amount of adsorbed gas is difficult to determine. To predict the adsorbed gas content of deep shales under formation conditions, isothermal adsorption experiments and model building were conducted on shale samples from Longmaxi Formation in China. A temperature-dependent adsorption model based on the Langmuir equation is proposed, which can be well-fitted by observed isotherms with a high correlation coefficient. Based on the fitted parameters at 303.15 K, the isothermal adsorption curves at 333.15 K, 363.15 K, and 393.15 K are predicted, showing a good agreement with experimental curves available. Compared with previous prediction methods, the biggest advantage of the proposed method is that it can be carried out only based on one-time isothermal adsorption experiment. Based on the predictions, the downward trend of the excess adsorption curves will slow down under high temperature and pressure conditions, and when the pressure reaches a certain level (> 80 MPa), the temperature has little effect on the excess adsorption capacity. While for absolute adsorption, the gas adsorption reaches saturation much slowly at high temperature, it can also reach saturation under formation pressure. Under the burial depth of marine shale, temperature plays a major role in controlling the adsorbed gas, resulting in the decrease of adsorbed gas content in deep shale, and its ratio will further decrease as the depth increases.
Cited as: Zhou, S., Wang, H., Li, B., Li, S., Sepehrnoori, K., Cai, J. Predicting adsorbed gas capacity of deep shales under high temperature and pressure: Experiments and modeling. Advances in Geo-Energy Research, 2022, 6(6): 482-491. https://doi.org/10.46690/ager.2022.06.05
Keywords
Full Text:
PDFReferences
Ambrose, R. J., Hartman, R. C., Diaz-Campos, M., et al. Shale gas-in-place calculations Part I: New pore-scale considerations. SPE Journal, 2012, 17: 219-229.
Bharath, R., Carl, T., Ramkumar, S. Simplified local density model for adsorption-over large pressure ranges. AIChE Journal, 1995, 41(4): 838-845.
Brunauer, S., Emmett, P.H., Teller, E., et al. Adsorption of gases in multimolecular layers. Journal of the American Chemical Society, 1938, 60: 309-319.
Cai, J., Tian, Z., Zhou, S., et al. Controlling factor analysis of microstructural property and storage capacity of deep Longmaxi Formation shale in Sichuan Basin. Energy & Fuels, 2021, 35(24): 20092-20102.
Chalmers, G. R., Bustin, R. M., Power, I. M. Characterization of gas shale pore systems by porosimetry, pycnometry, surface area, and field emission scanning electro microscopy/transmission electron microscopy image analyses: Examples from the Barnett, Woodford, Haynesville, Marcellus, and Doig units. AAPG Bulletin. 2012, 96: 1099-1119.
Chen, M., Kang, Y., Zhang, T., et al. Methane adsorption behavior on shale matrix at in-situ pressure and temperature conditions: Measurement and modeling. Fuel, 2018, 228: 39-49.
Cochran, T. W., Kabel, R. L., Danner, R. P. Vacancy solution theory of adsorption using Flory-Huggins activity coefficient equations. AIChE Journal, 1985, 31(2): 268-277.
Curtis, J. B. Fractured shale-gas systems. AAPG Bulletin, 2002, 86: 1921-1938.
Dong, D., Shi, Z., Guang, Q., et al. Progress, challenges and prospects of shale gas exploration in the Wufeng-Longmaxi reservoirs in the Sichuan Basin. Natural Gas Industry, 2018, 38(4): 67-76. (in Chinese)
Donohue, M. D., Aranovich, G. L. A New classification of isotherms for Gibbs adsorption of gases on solids. Fluid Phase Equilibria, 1999, 158-160: 557-563.
Duan, X., Hu, Z., Gao, S., et al. Shale high pressure isothermal adsorption curve and the production dynamic experiments of gas well. Petroleum Exploration and Development, 2018, 45(1): 127-135.
Dubinin, M. M., Stoeckli, F. Homogeneous and heterogeneous micropore structures in carbonaceous adsorbents. Journal of Colloid and Interface Science, 1980, 75(1): 34-42.
Fianu, J., Gholinezhad, J., Hassan, M. Comparison of temperature-dependent gas adsorption models and their application to shale gas reservoirs. Energy & Fuels, 2018, 32(4): 4763-4771.
Gasparik, M., Bertier, P., Gensterblum, Y., et al. Geological controls on the methane storage capacity in organic-rich shales. International Journal of Coal Geology, 2014, 123: 34-51.
Gasparik, M., Ghanizadeh, A., Gensterblum, Y., et al. Multi-temperature method for high-pressure sorption measurements on moist shales. Review of Scientific Instruments, 2013, 84(8): 085116.
Hartman, R. C., Ambrose, R. J., Akkutlu, I. Y., et al. Shale gas-in-place calculations part II-multi-component gas adsorption effects. Paper SPE 144097 Presented at North American Unconventional Gas Conference and Exhibition, The Woodlands, Texas, 14-16 June, 2011.
Huston, N. D., Yang, R. T. Theoretical basis for the Dubinin-Radushkevich (DR) adsorption isotherm equation. Adsorption, 1997, 3(3): 189-195.
Li, A., Han, W., Fang, Q., et al. Experimental investigation of methane adsorption and desorption in water-bearing shale. Advances in Geo-Energy Research, 2020, 3(3): 45-55.
Li, J., Li, B., Gao, Z., et al. Adsorption behavior, including the thermodynamic characteristics of wet shales under different temperatures and pressures. Chemical Engineering Science, 2021, 230: 116228.
Li, W., Li, J., Lu, S., et al. Evaluation of gas-in-place content and gas-adsorbed ratio using carbon isotope fractionation model: A case study from Longmaxi shales in Sichuan Basin, China. International Journal of Coal Geology, 2022, 249: 103881.
Liu, D., Yao, Y., Chang, Y. Measurement of adsorption phase densities with respect to different pressure: Potential application for determination of free and adsorbed methane in coalbed methane reservoir. Chemical Engineering Journal, 2022, 446(3): 137103.
Ma, X., Xie, J., Yong, R., et al. Geological characteristics and high production control factors of shale gas reservoirs in Silurian Longmaxi Formation, Southern Sichuan Basin, SW China. Petroleum Exploration and Development, 2020, 47(5): 901-915.
Ma, X., Wang, H., Zhou, S., et al. Deep shale gas in China: Geological characteristics and development strategies. Energy Reports, 2021, 7: 1903-1914.
Mengal, S. A., Wattenbarger, R. A. Accounting for adsorbed gas in shale gas reservoirs. Paper SPE 141085 Presented at SPE Middle East Oil and Gas Show and Conference, Manama, Bahrain, 25-28 September, 2011.
Ono, S., Kondo, S. Molecular theory of surface tension in liquids, in Structure of Liquids/Struktur der Flüssigkeiten, edited by Green H. S., et al., Springer, Berlin, Heidelberg, pp. 134-280, 1960.
Pan, Z., Connell, L. D. Reservoir simulation of free and adsorbed gas production from shale. Journal of Natural Gas Science and Engineering, 2015, 22: 359-370.
Pang, W., Jin, Z. Revisiting methane absolute adsorption in organic nanopores from molecular simulation and Ono-Kondo lattice model. Fuel, 2019, 235: 339-349.
Peter, J. C., Tim, A. M., Tennille, E. M. Influence of moisture content and temperature on methane adsorption isotherm analysis for coals from a low-rank, biogenically sourced gas reservoir. International Journal of Coal Geology, 2008, 76(1-2): 166-174.
Polanyi, M. The potential theory of adsorption. Science, 1963, 141(3585): 1010-1013.
Qin, X., Harpreet, S., Cai, J. Sorption characteristics in coal and shale: A review for enhanced methane recovery. Capillarity, 2022, 5(1): 1-11.
Rexer, T. F., Mathia, E. J., Aplin, A. C., et al. High-pressure methane adsorption and characterization of pores in Posidonia Shales and Isolated Kerogens. Energy & Fuels, 2014, 28(5): 2886-2901.
Ross, D. J. K., Bustin, R. M. The importance of shale composition and pore structure upon gas storage potential of shale gas reservoirs. Marine and Petroleum Geology, 2009, 26(6): 916-927.
Sakurovs, R., Day, S., Weir, S., et al. Application of a modified Dubinin-Radushkevich equation to adsorption of gases by coals under supercritical conditions. Energy & Fuels, 2007, 21(2): 992-997.
Sing, K. Adsorption methods for the characterization of porous materials. Advances in Colloid and Interface Science, 1998, 76(77): 3-11.
Wang, Z., Li, Y., Guo, P., et al. Analyzing the adaption of different adsorption models for describing the shale gas adsorption law. Chemical Engineering and Technology, 2016, 39(10): 1921-1932.
Wu, K., Li, X., Wang, C., et al. A model for surface diffusion of adsorbed gas in nanopores of shale gas reservoirs. Paper OTC 25662 Presented at Offshore Technology Conference, Houston, Texas, 4-7 May, 2015.
Wu, T., Zhao, H., Tesson, S., et al. Absolute adsorption of light hydrocarbons and carbon dioxide in shale rock and isolated kerogen. Fuel, 2019, 235: 855-867.
Xiang, Z., Liang, H., Qi, Z., et al. Mathematical model for isothermal adsorption of supercritical shale gas. Journal of Porous Media, 2019, 22(4): 499-510.
Xiong, J., Liu, X., Liang, L., et al. Adsorption of methane in organic-rich shale nanopores: An experimental and molecular simulation study. Fuel, 2017, 200: 299-315.
Xue, H., Wang, H., Liu, H., et al. Absorptivity capacity and aperture distribution characteristics of shales taking the Longmaxi Formation Shale of Sichuan Basin as an example. Acta Physica Sinica. 2013, 34(5): 826-832. (in Chinese)
Yang, Y., Liu, S., Clarkson, C. Quantification of temperature dependent sorption isotherms in shale gas reservoirs: Experiment and theory. Paper SPE 205897 Presented at SPE Annual Technical Conference and Exhibition, Dubai, UAE, 21-23 September, 2021.
Yu, W., Sepehrnoori, K., Patzek, T. W. Modeling gas adsorption in marcellus shale with Langmuir and BET Isotherms. SPE Journal, 2016, 21(2): 589-600.
Zhang, T., Ellis, G., Ruppel, S. C., et al. Effect of organic matter type and thermal maturity on methane adsorption in shale gas systems. Organic Geochemistry, 2012, 47: 120-131.
Zhang, C., Zhang, J., Li, W., et al. Deep shale reservoir characteristics and exploration potential of Wufeng-Longmaxi Formations in Dazu area, western Chongqing. Nature Gas Geoscience, 2019, 30(12): 1794-1804. (in Chinese)
Zhou, S., Ning, Y., Wang, H., et al. Investigation of methane adsorption mechanism on Longmaxi shale by combining the micropore filling and monolayer coverage theories. Advances in Geo-Energy Research, 2018, 2(3): 269-281.
Zhou, S., Liu, H., Chen, H., et al. A comparative study of the nanopore structure characteristics of coals and Longmaxi Shales in China. Energy Science and Engineering, 2019, 7(6), 2768-2781.
Zhu, L., Zhang, C., Zhang, Z., et al. High-precision calculation of gas saturation in organic shale pores using an intelligent fusion algorithm and a multi-mineral model. Advances in Geo-Energy Research, 2020, 4(2): 135-151.
Zou, C., Zhao, Q., Cong, L., et al. Development progress, potential and prospect of shale gas in China. Natural Gas Industry, 2021, 41(1): 1-14. (in Chinese)
DOI: https://doi.org/10.46690/ager.2022.06.05
Refbacks
- There are currently no refbacks.
Copyright (c) 2022 The Author(s)
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.