A multi-continuum model for simulating in-situ conversion process in low-medium maturity shale oil reservoir
Abstract view|107|times PDF download|102|times
Abstract
In-situ conversion is proposed applicable for low-medium maturity shale oil reservoir. However, parallel chemical kinetic reactions and evolution of shale pores during in-situ conversion make the numerical simulation a challenging problem. Although shale is typical multiscale and heterogeneous media, few models in previous studies take the difference between organic and inorganic system into consideration, which cannot simulate fluid flow accurately. In this paper, a multi-continuum model, considering coupled thermal-reactive compositional flow, is developed to simulate in-situ conversion process in low-medium maturity shale oil reservoir. The reaction of kerogen and hydrocarbon is quantified using kinetic reaction model. The evolution of fluid composition and shale properties are also incorporated. The accuracy of multiple-interacting-continua model and compositional model are demonstrated by comparing with commercial software and analytical solution. Then, the typical hexagon vertical well heating pattern is simulated and the feasibility is evaluated from an economic aspect. Finally, a series of case studies are conducted to investigate the impact of operation parameters on shale oil production.
Cited as: Wang, Z., Yao, J., Sun, H, Yan, X., Yang, Y. A multi-continuum model for simulating in-situ conversion process in low-medium maturity shale oil reservoir. Advances in Geo-Energy Research, 2021, 5(4): 456-464, doi: 10.46690/ager.2021.04.10
Keywords
Full Text:
PDFReferences
Barenblatt, G. I. Basic concepts in the theory of seepage of homogeneous liquids in fissured rocks. Journal of Applied Mathematics and Mechanics, 1960, 24(5): 1286-1303.
Bi, H., An, C., Chen, X., et al. Investigation into the oil removal from sand using a surface washing agent under different environmental conditions. Journal of Environmental Management, 2020, 275: 111232.
Braun, R. L., Burnham, A. K. Analysis of chemical reaction kinetics using a distribution of activation energies and simpler models. Energy & Fuels, 1987, 1(2): 153-161.
Braun, R. L., Burnham, A. K. Mathematical model of oil generation, degradation, and expulsion. Energy & Fuels, 1990, 4(1): 132-146.
Cheng, S., Huang, P., Wang, K., et al. Comprehensive modeling of multiple transport mechanisms in shale gas reservoir production. Fuel, 2020, 277: 118159.
Egboga, N., Kishore, K., Matthew, T. A feasibility study of thermal stimulation in unconventional shale reservoirs. Journal of Petroleum Science and Engineering, 2017, 154: 576-588.
Fan, W., Sun, H., Yao, J., et al. A new fractal transport model of shale gas reservoirs considering multiple gas transport mechanisms, multi-scale and heterogeneity. Fractals, 2018, 26: 1850096.
Fan, Y., Louis, D., Hamdi, A. Numerical simulation of the in-situ upgrading of oil shale. SPE Journal, 2010, 15(2): 368-381.
Farah, N., Ding, D., Wu, Y., et al. Simulation of fracturing water invasion and its impact on gas production in shale-gas reservoirs. Paper SPE 173264 Presented at ECMOR XIV-14th European conference on the mathematics of oil recovery, Catania, Sicily, 8-11 September, 2014.
Fowler, T., Harold, J. Oil shale ICP-Colorado field pilots. Paper SPE 121164 Presented at SPE western regional meeting, San Jose, California, 24-26 March, 2009.
Gao, Z., Fan, Y., Xuan, Q., et al. A review of shale pore structure evolution characteristics with increasing thermal maturities. Advances in Geo-Energy Research, 2020, 4(3): 247-259.
Garipov, T. T., Tomin, P., Rin, R., et al. Unified thermo-compositional-mechanical framework for reservoir simu-lation. Computational Geosciences, 2018, 22: 1039-1057.
Hazra, K., Lee, K., Economides, C., et al. Comparison of heating methods for in-situ oil shale extraction. Paper cp-342-00038 Presented at IOR 2013-17th European Symposium on Improved Oil Recovery, St. Petersburg, Russia, 16-18 April, 2013.
Jiang, J., Rami, M. A multimechanistic multicontinuum model for simulating shale gas reservoir with complex fractured system. Fuel, 2015, 161: 333-344.
Kibodeaux, K. Evolution of porosity, permeability, and fluid saturations during thermal conversion of oil shale. Paper SPE 170733 Presented at SPE annual technical conference and exhibition, Amsterdam, The Netherlands, 27-29 October, 2014.
Lee, K., George, J., Christine, A. A comprehensive simulation model of kerogen pyrolysis for the in-situ upgrading of oil shales. SPE Journal, 2016, 21: 1612-1630.
Lee, K., Stefan, F., George, J. Analyzing the impact of reaction models on the production of hydrocarbons from thermally upgraded oil shales. Journal of Petroleum Science and Engineering, 2018a, 168: 448-464.
Lee, K., Stefan, F., George, J. Estimating the reaction parameters of oil shale pyrolysis and oil shale grade using temperature transient analysis and inverse modeling. Journal of Petroleum Science and Engineering, 2018b, 165: 765-776.
Li, S., Wang, J., Wu, Z., et al. Study on reaction-kinetics of oil-shale and source-rock. Oil Shale, 1995, 12: 15-30.
Liu, L., Huang, Z., Yao, J., et al. An efficient hybrid model for 3D complex fractured vuggy reservoir simulation. SPE Journal, 2020a, 25(2): 907-924.
Liu, L., Huang, Z., Yao, J., et al. Simulating two-phase flow and geomechanical deformation in fractured karst reservoirs based on a coupled hydro-mechanical model. International Journal of Rock Mechanics and Mining Sciences, 2021a, 137: 104543.
Liu, L., Liu, Y., Yao, J., et al. Efficient coupled multiphase-flow and geomechanics modeling of well performance and stress evolution in shale-gas reservoirs considering dynamic fracture properties. SPE Journal, 2020b, 25(3): 1523-1542.
Liu, P., Li, J., Sun, S., et al. Numerical investigation of carbonate acidizing with gelled acid using a coupled thermal-hydrologic-chemical model. International Journal of Thermal Sciences, 2021b, 160: 106700.
Naraghi, M., Farzam, J. A stochastic permeability model for the shale-gas systems. International Journal of Coal Geology, 2015, 140: 111-124.
Oja, V., Eric, M. Oil shale processing, chemistry, and technology, in Fossil Energy, edit by R. Malhotra, Springer, New York, pp. 47-83, 2020.
Tatyana, P., Eduardo, G. Rigorous integrated evolutionary workflow for optimal exploitation of unconventional gas assets. International Journal of Energy Optimization and Engineering, 2017, 6(1): 101-121.
Tissot, B. P., Welte, D. H. Petroleum Formation and Occurrence. Berlin, German, Springer-Verlag Berlin Heidelberg, 2013.
Wang, J., Qian, J., Wu, L. Kinetic study on hydrocarbon forming pyrolysis of Fushun and Maoming oil shales. Paper CONF-840415 Presented at National Meeting of the American Chemical Society, St. Louis, MO, 8 April, 1984.
Wang, S., Feng, Q., Farzam, J., et al. Oil adsorption in shale nanopores and its effect on recoverable oil-in-place. International Journal of Coal Geology, 2015, 147: 9-24.
Wang, Z., Yao, J., Sun, H., et al. Coupled thermal-reactive flow simulation of in-Situ conversion in 3D low-mid maturity shale oil reservoir. Paper ARMA 21-2118 Presented at 55th US Rock Mechanics/Geomechanics Symposium, Houston, Texas, 20-23 June, 2021.
Warren, J., Root, P. The behavior of naturally fractured reservoirs. SPE Journal, 1963, 3(3): 245-255.
Wu, Y., Pruess, K. A multiple-porosity method for simulation of naturally fractured petroleum reservoirs. SPE Reservoir Engineering, 1988, 3(1): 327-336.
Yang, Y., Liu, X., Hang, H., et al. A review and research on comprehensive characterization of microscopic shale gas reservoir space. China Geology, 2019a, 2(4): 541-556.
Yang, Z., Zou, C., Wu, S., et al. Formation, distribution and resource potential of the “sweet areas (sections)” of continental shale oil in China. Marine and Petroleum Geology, 2019b, 102: 48-60.
Yan, X., Huang, Z., Yao, J., et al. An efficient numerical hybrid model for multiphase flow in deformable fractured-shale reservoirs. SPE Journal, 2018, 23: 1412-1437.
Zhang, M., Yao, J., Sun, H., et al. Triple-continuum modeling of shale gas reservoirs considering the effect of kerogen. Journal of Natural Gas Science and Engineering, 2015, 24: 252-263.
Zhao, W., Hu, S., Hou, L., et al. Types and resource potential of continental shale oil in China and its boundary with tight oil. Petroleum Exploration and Development, 2020, 47(1): 1-11.
Zhu, G., Li, A. Interfacial dynamics with soluble surfactants: A phase-field two-phase flow model with variable densities. Advances in Geo-Energy Research, 2020, 4(1): 86-98.
Refbacks
- There are currently no refbacks.
Copyright (c) 2021 The Author(s)
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.