Shear thickening effects of drag-reducing nanofluids for low permeability reservoir
Abstract view|446|times PDF download|269|times
Abstract
Drag-reducing nanofluids are complex non-Newtonian fluids. Their constitutive characteristics are the basis of flow mechanism analysis in porous media. However, the rheological effects of drag-reducing nanofluids have not been thoroughly studied. In the present work, rheological properties of several nanofluids were measured, and the shear thickening mechanism was investigated experimentally. The results show that all the nanofluids examined have complex characteristics and critical shear rates. The viscosity exhibits a slow linear increase with the shear rate below the critical shear rate, while the shear thickening power-law fluid behaviour appears above the critical shear rate. The critical shear rate increases with the increase of particle concentration, which indicates the injection rate needs to be controlled to avoid significant increase of nanofluids viscosity. The rheological curve of increasing shear rate nearly coincides with that of decreasing shear rate, which indicates that the shear thickening of nanofluids studied in this work is transient and reversible. A constant index constitutive equation with an exponent of 0.5 is obtained from test results by the fixed index method, and its coefficient k(c) is a linear function of the concentration, which can replace a set of conventional constitutive equations with different concentrations. The constant index constitutive equation also clarifies the coefficient dimension. Similar results have been obtained by analysing several other nanofluids using the fixed index method, which validates the new effective method for constructing the constitutive equations of non-Newtonian nanofluids.
Cited as: Gu, C., Qiu, R., Liu, S., You, Z., Qin, R. Shear thickening effects of drag-reducing nanofluids for low permeability reservoir. Advances in Geo-Energy Research, 2020, 4(3): 317-325, doi: 10.46690/ager.2020.03.09
Keywords
Full Text:
PDFReferences
Aladag, B., Halelfadl, S., Doner, N., et al. Experimental investigations of the viscosity of nanofluids at low temperatures. Appl. Energy 2012, 97: 876-880.
Alnarabiji, M.S., Husein, M.M. Application of bare nanoparticle-based nanofluids in enhanced oil recovery. Fuel 2020, 267: 117262.
Alphonse, P., Bleta, R., Soules, R. Effect of PEG on rheology on stability of nanocrystalline titania hydrosols. J. Colloid Interface Sci. 2009, 337(1): 81-87.
Assef, Y., Arab, D., Pourafshary, P. Application of nanofluid to control fines migration to improve the performance of low salinity water flooding and alkaline flooding. J. Pet. Sci. Eng. 2014, 124: 331-340.
Baghbanzadeh, M., Rashidi, A., Soleimanisalim, A.H., et al. Investigating the rheological properties of nanofluids of water/hybrid nanostructure of spherical silica/MWCNT. Thermochim. Acta 2014, 578: 53-58.
Bossis, G., Brady, J.F. The rheology of Brownian suspensions. J. Chem. Phys. 1989, 91(3): 1866-1874.
Cao, S., Zhang, D., Shi, L., et al. The micro-dispersion research of nano-augmented injection microemulsion. Journal of Function Materials, 2010, 41(12): 2210-2212. (in Chinese)
Catherall, A.A., Melrose, J.R., Ball, R.C. Shear thickening and order-disorder effects in concentrated colloids at high shear rates. J. Rheol. 2000, 44(1): 1-25.
Cheng, Y., Li X., Li Q., et al. Preparation and performance of water-based nanometer polysilicon as augmented injection for oil field. chemical research, 2006, 17(4): 56-59. (in Chinese)
Chen, H., Ding, Y. Heat transfer and rheological behaviour of nanofluids-a review. in Advances in transport phenomena, edited by L.Q. Wang, Springer, Berlin, Heidelberg, pp. 135-177, 2009.
Chen, H., Di, Q., Ye, F., et al. Numerical simulation of drag reduction effects by hydrophobic nanoparticles adsorption method in water flooding processes. J. Nat. Gas Sci. Eng. 2016, 35: 1261-1269.
Chan C.F., Mong F. Some constitutive Equations for non-Newtonian fluids. Chinese Journal of Theoretical and Applied Mechanics, 1983, 19(1): 16-26. (in Chinese)
Das, S.K., Putra, N., Thiesen, P., et al. Temperature dependence of thermal conductivity enhancement for nanofluids. J. Heat Transf. 2003, 125(4): 567-574.
Ettefaghi, E., Rashidi, A., Ahmadi, H., et al. Thermal and rheological properties of oil-based nanofluids from different carbon nanostructures. Int. Commun. Heat Mass Transf. 2013; 48: 178-182.
Gu, C., Di, Q., Fang, H. Slip velocity model of porous walls absorbed by hydrophobic nanoparticles SiO2. J. Hydrodyn. 2007, 19(3): 365-371.
Gu, C., Di, Q., Shi, L., et al. Drag Reduction Technology with Nanomaterial ShUNP2-10 in Oilfield. Adv. Mater. Res. 2013, 807-809: 2492-2497.
Heine, D.R., Petersen M.K., Grest G.S. Effect of particle shape and charge on bulk rheology of nanoparticle suspensions. J. Chem. Phys. 2010, 132(18): 184509.
He, Y., Jin, Y., Chen, H.S., et al. Heat transfer and flow behaviour of aqueous suspensions of TiO2 nanoparticles (nanofluids) flowing upward through a vertical pipe. Int. J. Heat Mass Transf. 2007, 50(11-12): 2272-2281.
Hong, R.Y., Ren, Z.Q., Han, Y.P., et al. Rheological properties of water-based Fe3O4 ferrofluids. Chem. Eng. Sci. 2007, 62(21): 5912-5924.
Hu, X., Li, S., Wu, H. The application of poly-silicon mano-augmented injection technology in high-salt sensitivity reservoirs in jiangling depression. Journal of Oil and Gas Technology 2012, 34(7): 129-131. (in Chinese)
Jo ´zwiak, B., Boncel, S. Rheology of ionanofluids-A review. J. Mol. Liq. 2020, 302: 112568.
Ju, B.S., Dai S.G., Luan Z.A., et al. A study of wettability and permeability change caused by adsorption of nanometer structured polysilicon on the surface of porous media. Paper SPE-77938-MS Presented at SPE Asia Pacific Oil and Gas Conference and Exhibition, Melbourne, Australia, 8-10 October, 2002.
Lu, K. Rheological behaviour of carbon nanotube-alumina nanoparticle dispersion systems. Powder Technol. 2007, 177(3): 154-161.
Lu, X., Lv, G., Luan, Z., et al. Application of polysilicon in low permeability oil field. Ptroleum Exploration and Development 2003, 30(6): 110-122. (in Chinese)
Maranzano, B.J., Wagner, N.J. Flow-small angle neutron scattering measurements of colloidal dispersion microstructure evolution through the shear thickening transition. J. Chem. Phys. 2002, 117(22): 10291-10302.
Maranzano, B.J., Wagner, N.J. The effect of particle size on reversible shear thickening of concentrated colloidal dispersions. J. Chem. Phys. 2001, 114(23): 10514-10527.
Moattar, M.T.Z., Cegincara, R.M. Stability, rheological, magnetorheological and volumetric characterizations of polymer based magnetic nanofluids. Colloid Polym. Sci. 2013, 291(8): 1977-1987.
Moghadasi, R., Rostami, A., Hemmati-Sarapardeh, A. Application of nanoflfluids for treating fines migration during hydraulic fracturing: Experimental study and mechanistic understanding. Adv. Geo-Energy Res. 2019, 3(2): 198-206.
Moghaddam, M.B., Goharshadi, E.K., Entezari,, M.H., et al. Preparation, characterization and rheological properties of grapheme-glycerol nanofluids. Chem. Eng. J. 2013, 231: 365-372.
Mohamadian, N., Ghorbani, H., Wood, D.A., et al. Rheological and filtration characteristics of drilling fluids enhanced by nanoparticles with selected additives: an experimental study. Adv. Geo-Energy Res. 2018, 2(3): 228-236.
Muhammad, Z.H., Daisuke, H., Akira, Y., et al. Dispersion and rheology of nanofluids with various concentrations of organic modified nanoparticles: Modifier and solvent effects. Colloid Surf. A. 2019, 583: 123876.
Navarrete, N., Hernandez, L., Vela, A., et al. Influence of the production method on the thermophysical properties of high temperature molten salt-based nanofluids, J. Mol. Liq. 2020, 302: 112570.
Pang, D., Gu, C., Di, Q., et al. Research of rheology of friction-reducing nano silicon dioxide fluid. Journal Xi an Shiyou University (Natural Science Edition) 2016, 31(5) : 78-83. (in Chinese)
Petel, O.E., Ouellet, S., Loiseau, J., et al., The effect of particle strength on the ballistic resistance of shear thickening fluids. Appl. Phys. Lett. 2013, 102(6): 064103.
Sharma, A.K., Tiwari, A.K., Dixit, A.R. Rheological behaviour of nanofluids: A review. Renew. Sust. Energ. Rev. 2016, 53: 779-791.
Sha, X. Preparation and properties research of shear thicking liquid. Wuxi: Jiangnan University, 2013. (in Chinese)
Susan-Resiga, D., Socoliuc, V., Boros, T., et al. The influence of particle clustering on the rheological properties of highly concentrated magnetic nanofluids. J. Colloid Interface Sci. 2012, 373(1): 110-115.
Wang, J., Wang, Z., Lei, S., et al. Research on the influence of different pretreatment technology on augmented injection effect of nanometer polysilicon material. Petrochemical Industry Application 2012, 31(2): 76-79. (in Chinese)
Wang, J., Zhu, J., Zhang, X., et al. Heat transfer and pressure drop of nanofluids containing carbon nanotubes in laminar flows. Exp. Therm. Fluid Sci. 2013, 44: 716-721.
Wang, L., Chen, H., Witharana, S. Rheology of nanofluids: a review. Recent Pat. Nanotechnology 2013, 7(3): 232-246.
Wang, X., Xu, X., Choi, S. Thermal conductivity of nanoparticle-fluid mixture. J. Thermophys. Heat Transf. 1999, 13(4): 474-480.
Yang, Y., Grulke, E.A., Zhang, Z.G., et al. Thermal and rheological properties of carbon nanotube in oil dispersions. J. Appl. Phys. 2006, 99(11): 114307.
Yuan, S., Wang Q. New progress and prospect of oilfields development technologies in China. Pet. Explor. Dev. 2018, 45(4): 698-711.
Yue, Y. Development of a new water-based nano-polysilicon injection enhance. Chengdu, Southwest Petroleum University, 2014. (in Chinese)
Yu, Q., Zheng N., Song, J., et al. Application of water-based nano-polysilicon emulsion. Oilfield Chemistry, 2012, 29(2): 181-185. (in Chinese)
Zhao, M., Lv, W., Li, Y., et al. Study on the synergy between silica nanoparticles and surfactants for enhanced oil recovery during spontaneous imbibition. J. Mol. Liq. 2018, 261: 373-378.
DOI: https://doi.org/10.46690//ager.2020.03.09
Refbacks
- There are currently no refbacks.
Copyright (c) 2020 The Author(s)
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.